The Wayro route from Nogales to San Carlos is 262 miles (422 km), about 4 h 42 min of driving without stops. The U.S.–Mexico border is at about mile 2 on this route, near the Nogales port of entry.
| Distance | 262 mi (422 km) |
|---|---|
| Driving time, no stops | 4 h 42 min |
| Main roads, in order | MEX-15 → MEX-15D → SON 124 |
| Border crossing | about mile 2 of this route, Arizona → Sonora (near the Nogales, AZ port of entry) |
| Mexican states on the route | Sonora (Level 3) |
| Toll roads | MEX-15D |
| Fuel estimate (car at 25 mpg) | about 10.5 gal; actual use varies by vehicle and traffic |
| Stops listed below | 0 |
Crossing into Mexico: what you need for San Carlos
| Passport | Passport book or passport card to enter Mexico by land |
|---|---|
| FMM entry permit | Required for this trip: San Carlos is well beyond the 12-mile (20 km) border zone where the permit is not needed |
| Temporary vehicle import permit (TIP) | Not needed: San Carlos is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit |
| Mexican auto insurance | Required for all vehicles: buy a Mexican policy before you cross |
Sources: U.S. State Department, Mexico travel information (updated August 11, 2026); permits are issued by Banjercito. Sonora free zone: Explore Sonora.
Crossing at Nogales
Nogales, Arizona, and Nogales, Sonora, share several crossings: DeConcini downtown is the main gateway for visitors and daily crossers, Morley Gate nearby serves pedestrians, and Mariposa on the west side handles commercial trucks. The city is also home to Arizona's only rail crossing.
What the drive from Nogales to San Carlos is like
MEX-15D (139 mi) and MEX-15 (115 mi) carry about 97% of the 262 miles. The U.S. part of the drive runs through Arizona for about 2 miles; after the border at Nogales you have about 260 miles left in Mexico. The Mexican leg uses MEX-15D, a toll highway (cuota).
The route from Nogales to San Carlos, road by road
| Road | Route miles (from–to) | Length, mi | State |
|---|---|---|---|
| local roads | 0–1 | 1 | Arizona |
| MEX-15 | 1–52 | 51 | Arizona, Sonora |
| MEX-15D | 52–191 | 139 | Sonora |
| MEX-15 | 191–255 | 64 | Sonora |
| connecting roads | 255–256 | 1 | Sonora |
| SON 124 | 256–262 | 6 | Sonora |
- Mile 2 of this route: Arizona → Sonora (international border)
When you get to San Carlos
San Carlos is a Pueblo Mágico on the Sea of Cortez in Sonora, a short drive from the port of Guaymas, where desert hills run straight down to the water. The Guaymas city government highlights its white-sand beaches, the Tetakawi hill and the El Soldado estuary, and offshore Isla San Pedro Nolasco draws snorkelers and divers.
- Cerro Tetakawi: The landmark hill above the bay is a hiking destination with views over the bay from its summit. source
- Playa Los Algodones: Los Algodones heads a list of local white-sand beaches that also includes San Francisco, Piedras Pintas, La Manga and El Tomate. source
- Estero El Soldado: This 322-hectare protected estuary shelters more than 116 species of migratory birds, and its mangroves can be explored by kayak or paddleboard. source
More drives to San Carlos
- Wickenburg, AZ to San Carlos
- Surprise, AZ to San Carlos
- Apache Junction, AZ to San Carlos
- Phoenix, AZ to San Carlos
- Gilbert, AZ to San Carlos
- Globe, AZ to San Carlos
From Nogales to other places in Mexico
- Nogales, AZ to San Quintín
- Nogales, AZ to Nuevo Casas Grandes
- Nogales, AZ to Rosarito
- Nogales, AZ to El Fuerte
- Nogales, AZ to San Luis Río Colorado
- Nogales, AZ to Cananea
All routes to San Carlos, border crossings and permits in one place: Driving to San Carlos, Mexico from the U.S.
Continue Your Adventure
Frequently asked questions
How long is the drive from Nogales to San Carlos?
About 4 h 42 min of driving without stops, over 262 miles.
How far is San Carlos from Nogales by car?
About 262 miles (422 km) on the Wayro route. Other map services may show a few miles more or less, depending on where they start and end in each city.
Where does the Nogales to San Carlos drive cross into Mexico?
At about mile 2 of this route, from Arizona into Sonora, near the Nogales port of entry.
Do I need a permit to drive my car from Nogales to San Carlos?
No vehicle permit is needed. San Carlos is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit. You also need Mexican auto insurance and a passport book or card. An FMM entry permit is required too.
Is it safe to drive from Nogales to San Carlos?
The U.S. State Department rates Sonora Level 3: Reconsider Travel (advisory issued May 29, 2026). Read the full advisory before you go.
What roads does the drive from Nogales to San Carlos use?
In order: MEX-15, MEX-15D and SON 124. The road-by-road table above shows the route miles and states for each one.
How we put this guide together
Wayro calculates the route from OpenStreetMap road data; mile numbers are positions along this route, not highway mile markers, and "from the route" distances are straight-line, so the real detour depends on access roads. Stops are chosen from parks, natural sites, museums, historic sites and attractions close to the route (roughly 2 to 7 miles depending on the type, farther for World Heritage sites): at least one strong stop for each stretch of the drive, then the best-known places nearest the road, with no more than five of one type, up to nine in all. Places that are closed, private or not open to visitors are removed. Place and city descriptions are written by the Wayro team from official park, museum, tourism and government websites and other published sources. Safety levels and entry rules were checked against the U.S. Department of State on September 29, 2026. Conditions change, so check the linked sources before you travel.
Route data © OpenStreetMap contributors.