The Wayro route from Globe to San Carlos is 430 miles (692 km), about 8 h 7 min of driving without stops. The U.S.–Mexico border is at about mile 170 on this route, near the Nogales port of entry.
| Distance | 430 mi (692 km) |
|---|---|
| Driving time, no stops | 8 h 7 min |
| Main roads, in order | AZ 77 → I-19 → MEX-15D → MEX-15 → SON 124 |
| Border crossing | about mile 170 of this route, Arizona → Sonora (near the Nogales, AZ port of entry) |
| Mexican states on the route | Sonora (Level 3) |
| Toll roads | MEX-15D |
| Fuel estimate (car at 25 mpg) | about 17.2 gal; actual use varies by vehicle and traffic |
| Stops listed below | 7 |
Crossing into Mexico: what you need for San Carlos
| Passport | Passport book or passport card to enter Mexico by land |
|---|---|
| FMM entry permit | Required for this trip: San Carlos is well beyond the 12-mile (20 km) border zone where the permit is not needed |
| Temporary vehicle import permit (TIP) | Not needed: San Carlos is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit |
| Mexican auto insurance | Required for all vehicles: buy a Mexican policy before you cross |
Sources: U.S. State Department, Mexico travel information (updated August 11, 2026); permits are issued by Banjercito. Sonora free zone: Explore Sonora.
Crossing at Nogales
Nogales, Arizona, and Nogales, Sonora, share several crossings: DeConcini downtown is the main gateway for visitors and daily crossers, Morley Gate nearby serves pedestrians, and Mariposa on the west side handles commercial trucks. The city is also home to Arizona's only rail crossing.
What the drive from Globe to San Carlos is like
MEX-15D (147 mi) and MEX-15 (107 mi) carry about 59% of the 430 miles. The U.S. part of the drive runs through Arizona for about 170 miles; after the border at Nogales you have about 260 miles left in Mexico. The Mexican leg uses MEX-15D, a toll highway (cuota). Of the 7 stops listed below, 6 are within a mile of the road.
The route from Globe to San Carlos, road by road
| Road | Route miles (from–to) | Length, mi | State |
|---|---|---|---|
| local roads | 0–4 | 4 | Arizona |
| AZ 77 | 4–101 | 97 | Arizona |
| connecting roads | 101–106 | 5 | Arizona |
| I-19 | 106–166 | 60 | Arizona |
| connecting roads | 166–169 | 3 | Arizona |
| MEX-15D | 169–177 | 8 | Arizona, Sonora |
| MEX-15 | 177–220 | 43 | Sonora |
| MEX-15D | 220–359 | 139 | Sonora |
| MEX-15 | 359–423 | 64 | Sonora |
| connecting roads | 423–424 | 1 | Sonora |
| SON 124 | 424–430 | 6 | Sonora |
- Mile 170 of this route: Arizona → Sonora (international border)
Stops between Globe and San Carlos
- Right off the route (under 1 mile): Tohono Chul Park (mile 95), Cathedral of Saint Augustine (mile 104), Mission San Xavier del Bac (mile 112), Tubac Presidio State Historic Park (mile 147), Tumacácori National Historical Park (mile 150), Mission San Cayetano de Calabazas (mile 160)
- Nature and outdoors: Catalina State Park (mile 88), Tohono Chul Park (mile 95), Tubac Presidio State Historic Park (mile 147), Tumacácori National Historical Park (mile 150)
- Museums and history: Cathedral of Saint Augustine (mile 104), Mission San Xavier del Bac (mile 112), Tumacácori National Historical Park (mile 150), Mission San Cayetano de Calabazas (mile 160)
Catalina State Park
Covering 5,500 acres of foothills and canyons at the base of the Santa Catalina Mountains near Tucson, the park has thousands of saguaros, more than 150 bird species, trails for hiking, biking, and horseback riding, and guided walks at the Hohokam Romero Ruin.
Tohono Chul Park
Tohono Chul is a 49-acre Sonoran Desert botanical garden and nature preserve in the Tucson area, with themed gardens, desert trails, art galleries, a bistro and a children's museum. It opened to the public in 1985.
Cathedral of Saint Augustine
Mother church of the Diocese of Tucson, this downtown cathedral wears a 1928 cast-stone façade inspired by the Cathedral of Querétaro, Mexico, decorated with yucca and saguaro blossoms and a depiction of Mission San Xavier del Bac.
Mission San Xavier del Bac
Founded in 1692 by Father Eusebio Kino on what is now the Tohono O'odham Nation's San Xavier Reservation, the mission's white church, built 1783–1797, is a National Historic Landmark and active parish open to visitors.
Tubac Presidio State Historic Park
Known as Arizona's first state park, dedicated in 1958, it preserves ruins of the Spanish presidio founded in 1752. See the museum, an underground archaeology exhibit, and an 1885 territorial schoolhouse.
Tumacácori National Historical Park
An adobe mission church anchors this park in the Santa Cruz River valley, where O'odham, Yaqui, and Apache people met Jesuit and Franciscan missionaries. Tour the mission grounds and visitor center, then walk the Anza Trail along the river.
Mission San Cayetano de Calabazas
Part of Tumacácori National Historical Park, these adobe church ruins date to a Pima settlement established in 1756 and abandoned in 1786 after Apache raids. The site can only be visited on a reserved ranger-led tour.
When you get to San Carlos
San Carlos is a Pueblo Mágico on the Sea of Cortez in Sonora, a short drive from the port of Guaymas, where desert hills run straight down to the water. The Guaymas city government highlights its white-sand beaches, the Tetakawi hill and the El Soldado estuary, and offshore Isla San Pedro Nolasco draws snorkelers and divers.
- Cerro Tetakawi: The landmark hill above the bay is a hiking destination with views over the bay from its summit. source
- Playa Los Algodones: Los Algodones heads a list of local white-sand beaches that also includes San Francisco, Piedras Pintas, La Manga and El Tomate. source
- Estero El Soldado: This 322-hectare protected estuary shelters more than 116 species of migratory birds, and its mangroves can be explored by kayak or paddleboard. source
More drives to San Carlos
- Wickenburg, AZ to San Carlos
- Surprise, AZ to San Carlos
- Apache Junction, AZ to San Carlos
- Phoenix, AZ to San Carlos
- Gilbert, AZ to San Carlos
- Bisbee, AZ to San Carlos
From Globe to other places in Mexico
- Globe, AZ to Tecate
- Globe, AZ to Magdalena de Kino
- Globe, AZ to Nuevo Casas Grandes
- Globe, AZ to Rosarito
- Globe, AZ to Guaymas
- Globe, AZ to San Felipe
All routes to San Carlos, border crossings and permits in one place: Driving to San Carlos, Mexico from the U.S.
Frequently asked questions
How long is the drive from Globe to San Carlos?
About 8 h 7 min of driving without stops, over 430 miles.
How far is San Carlos from Globe by car?
About 430 miles (692 km) on the Wayro route. Other map services may show a few miles more or less, depending on where they start and end in each city.
Where does the Globe to San Carlos drive cross into Mexico?
At about mile 170 of this route, from Arizona into Sonora, near the Nogales port of entry.
Do I need a permit to drive my car from Globe to San Carlos?
No vehicle permit is needed. San Carlos is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit. You also need Mexican auto insurance and a passport book or card. An FMM entry permit is required too.
Is it safe to drive from Globe to San Carlos?
The U.S. State Department rates Sonora Level 3: Reconsider Travel (advisory issued May 29, 2026). Read the full advisory before you go.
What roads does the drive from Globe to San Carlos use?
In order: AZ 77, I-19, MEX-15D, MEX-15 and SON 124. The road-by-road table above shows the route miles and states for each one.
What are good stops between Globe and San Carlos?
Closest to the road: Tohono Chul Park (botanical garden, mile 95, 0.3 mi from the route); Tubac Presidio State Historic Park (state park, mile 147, 0.4 mi from the route); Tumacácori National Historical Park (National Historical Park, mile 150, 0.2 mi from the route). All stops are described above.
How we put this guide together
Wayro calculates the route from OpenStreetMap road data; mile numbers are positions along this route, not highway mile markers, and "from the route" distances are straight-line, so the real detour depends on access roads. Stops are chosen from parks, natural sites, museums, historic sites and attractions close to the route (roughly 2 to 7 miles depending on the type, farther for World Heritage sites): at least one strong stop for each stretch of the drive, then the best-known places nearest the road, with no more than five of one type, up to nine in all. Places that are closed, private or not open to visitors are removed. Place and city descriptions are written by the Wayro team from official park, museum, tourism and government websites and other published sources. Safety levels and entry rules were checked against the U.S. Department of State on September 29, 2026. Conditions change, so check the linked sources before you travel.
Route data © OpenStreetMap contributors.