The Wayro route from Orderville to Sonoyta is 513 miles (826 km), about 10 h 2 min of driving without stops. The U.S.–Mexico border is at about mile 511 on this route, near the Lukeville port of entry.
| Distance | 513 mi (826 km) |
|---|---|
| Driving time, no stops | 10 h 2 min |
| Main roads, in order | US-89 → I-40 → I-17 → AZ 303 → I-10 → AZ 85 → US-80 Hist |
| Border crossing | about mile 511 of this route, Arizona → Sonora (near the Lukeville, AZ port of entry) |
| Mexican states on the route | Sonora (Level 3) |
| Fuel estimate (car at 25 mpg) | about 20.5 gal; actual use varies by vehicle and traffic |
| Stops listed below | 8 |
Crossing into Mexico: what you need for Sonoyta
| Passport | Passport book or passport card to enter Mexico by land |
|---|---|
| FMM entry permit | Not needed if you stay within 12 miles (20 km) of the border for 6 days or less; required for longer stays or if you travel farther in |
| Temporary vehicle import permit (TIP) | Not needed: Sonoyta is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit |
| Mexican auto insurance | Required for all vehicles: buy a Mexican policy before you cross |
Sources: U.S. State Department, Mexico travel information (updated August 11, 2026); permits are issued by Banjercito. Sonora free zone: Explore Sonora.
Crossing at Lukeville
Lukeville is a small port at the south end of Arizona State Route 85, across from Sonoyta, Sonora. It is the main road gateway for Arizonans heading to Puerto Peñasco (Rocky Point) on the Sea of Cortez, via Mexico Federal Highway 8.
What the drive from Orderville to Sonoyta is like
US-89 (224 mi) and I-17 (115 mi) carry about 66% of the 513 miles. The U.S. part of the drive runs through Utah, Arizona for about 511 miles; after the border at Lukeville you have about 2 miles left in Mexico. Of the 8 stops listed below, 2 are within a mile of the road.
The route from Orderville to Sonoyta, road by road
| Road | Route miles (from–to) | Length, mi | State |
|---|---|---|---|
| US-89 | 0–224 | 224 | Utah, Arizona |
| I-40 | 224–229 | 5 | Arizona |
| connecting roads | 229–231 | 2 | Arizona |
| I-17 | 231–346 | 115 | Arizona |
| connecting roads | 346–350 | 4 | Arizona |
| AZ 303 | 350–382 | 32 | Arizona |
| connecting roads | 382–383 | 1 | Arizona |
| I-10 | 383–393 | 10 | Arizona |
| connecting roads | 393–394 | 1 | Arizona |
| AZ 85 | 394–398 | 4 | Arizona |
| US-80 Hist | 398–427 | 29 | Arizona |
| AZ 85 | 427–510 | 83 | Arizona |
| local roads | 510–513 | 3 | Arizona, Sonora |
- Mile 86 of this route: Utah → Arizona (state line)
- Mile 511 of this route: Arizona → Sonora (international border)
Stops between Orderville and Sonoyta
- Right off the route (under 1 mile): Montezuma Castle National Monument (mile 278), Organ Pipe Cactus National Monument (mile 505)
- Nature and outdoors: Glen Canyon National Recreation Area (mile 89), Glen Canyon (mile 100), Walnut Canyon National Monument (mile 224), Oak Creek Canyon (mile 245)
- Museums and history: Wupatki National Monument (mile 198), Walnut Canyon National Monument (mile 224), Montezuma Castle National Monument (mile 278), Organ Pipe Cactus National Monument (mile 505)
Glen Canyon National Recreation Area
Stretching from Lees Ferry in Arizona to Utah's Orange Cliffs, this 1.25-million-acre recreation area wraps Lake Powell and includes Horseshoe Bend, the Glen Canyon Dam and access to Rainbow Bridge National Monument.
Glen Canyon
Flooded by Lake Powell behind Glen Canyon Dam, this Colorado River canyon anchors a recreation area of more than 1.25 million acres, with houseboating, kayaking, Horseshoe Bend's 270-degree river bend and dam tours near Page.
Wupatki National Monument
Ancestral Pueblo people built a busy center of trade here in the early 1100s. Trails lead to Wupatki Pueblo, with more than 100 rooms, a ball court and a natural blowhole, plus the Wukoki, Lomaki and Citadel pueblos.
Walnut Canyon National Monument
Cliff dwellings built between 1125 and 1250 CE line this canyon near Flagstaff. The Island Trail descends 240 stairs past 25 of them, while the shorter Rim Trail offers wide views of the canyon and its dwellings.
Lowell Observatory
Percival Lowell founded this Mars Hill observatory in Flagstaff in 1894, and Clyde Tombaugh discovered Pluto here in 1930; today visitors can see the Pluto Discovery Dome and look through public telescopes at the Open Deck Observatory.
Oak Creek Canyon
Between Sedona and Flagstaff, State Route 89A follows this red-rock gorge for about 15 miles, climbing roughly 2,200 feet with hairpin turns and passing Midgley Bridge, Oak Creek Vista, and Slide Rock State Park.
Montezuma Castle National Monument
Tucked into an alcove about 90 feet up a limestone cliff, this 20-room Sinagua dwelling is viewed from below. Established in 1906, the monument also includes Montezuma Well, a separate unit that once supplied the Sinagua with water.
Organ Pipe Cactus National Monument
Near Ajo in the Sonoran Desert, this International Biosphere Reserve is the only place in the U.S. to see large stands of organ pipe cactus, with scenic drives, hiking trails, camping, and winter ranger programs.
When you get to Sonoyta
Sonoyta is the Sonoran border town opposite Lukeville, Arizona, a few miles south of Organ Pipe Cactus National Monument, and it is where Federal Highway 8 turns south toward Puerto Peñasco. That road leads to the visitor center of El Pinacate and Gran Desierto de Altar, a UNESCO World Heritage biosphere reserve of lava fields, giant craters and sand dunes.
- El Pinacate and Gran Desierto de Altar Biosphere Reserve: Inscribed by UNESCO in 2013, the reserve protects a dormant volcanic shield, ten deep circular craters and dunes up to 200 meters high. source
- El Elegante crater: The reserve's managers call El Elegante its most visited and most accessible crater; the visitor center is at km 52 of the Sonoyta–Puerto Peñasco highway. source
- Organ Pipe Cactus National Monument: Just across the border in Arizona, the monument's Kris Eggle Visitor Center is five miles north of the Lukeville crossing, and the park fronts 30 miles of the border. source
More drives to Sonoyta
- Lake Havasu City, AZ to Sonoyta
- Escondido, CA to Sonoyta
- Kanab, UT to Sonoyta
- Venice Beach, CA to Sonoyta
- Bisbee, AZ to Sonoyta
- Camarillo, CA to Sonoyta
From Orderville to other places in Mexico
- Orderville, UT to Tecate
- Orderville, UT to San Luis Río Colorado
- Orderville, UT to Rosarito
- Orderville, UT to Tijuana
- Orderville, UT to Mexicali
- Orderville, UT to Puerto Peñasco
All routes to Sonoyta, border crossings and permits in one place: Driving to Sonoyta, Mexico from the U.S.
Continue Your Adventure
Frequently asked questions
How long is the drive from Orderville to Sonoyta?
About 10 h 2 min of driving without stops, over 513 miles.
How far is Sonoyta from Orderville by car?
About 513 miles (826 km) on the Wayro route. Other map services may show a few miles more or less, depending on where they start and end in each city.
Where does the Orderville to Sonoyta drive cross into Mexico?
At about mile 511 of this route, from Arizona into Sonora, near the Lukeville port of entry.
Do I need a permit to drive my car from Orderville to Sonoyta?
No vehicle permit is needed. Sonoyta is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit. You also need Mexican auto insurance and a passport book or card.
Is it safe to drive from Orderville to Sonoyta?
The U.S. State Department rates Sonora Level 3: Reconsider Travel (advisory issued May 29, 2026). Read the full advisory before you go.
What roads does the drive from Orderville to Sonoyta use?
In order: US-89, I-40, I-17, AZ 303, I-10, AZ 85 and US-80 Hist. The road-by-road table above shows the route miles and states for each one.
What are good stops between Orderville and Sonoyta?
Closest to the road: Lowell Observatory (astronomical observatory, mile 228, 2 mi from the route); Montezuma Castle National Monument (National monument, mile 278, 0.6 mi from the route); Organ Pipe Cactus National Monument (National monument, mile 505, 0.2 mi from the route). All stops are described above.
How we put this guide together
Wayro calculates the route from OpenStreetMap road data; mile numbers are positions along this route, not highway mile markers, and "from the route" distances are straight-line, so the real detour depends on access roads. Stops are chosen from parks, natural sites, museums, historic sites and attractions close to the route (roughly 2 to 7 miles depending on the type, farther for World Heritage sites): at least one strong stop for each stretch of the drive, then the best-known places nearest the road, with no more than five of one type, up to nine in all. Places that are closed, private or not open to visitors are removed. Place and city descriptions are written by the Wayro team from official park, museum, tourism and government websites and other published sources. Safety levels and entry rules were checked against the U.S. Department of State on September 29, 2026. Conditions change, so check the linked sources before you travel.
Route data © OpenStreetMap contributors.