The Wayro route from Bisbee to Sonoyta is 245 miles (395 km), about 4 h 59 min of driving without stops. The U.S.–Mexico border is at about mile 244 on this route, near the Lukeville port of entry.
| Distance | 245 mi (395 km) |
|---|---|
| Driving time, no stops | 4 h 59 min |
| Main roads, in order | AZ 80 → AZ 90 → I-10 → AZ 86 → AZ 85 |
| Border crossing | about mile 244 of this route, Arizona → Sonora (near the Lukeville, AZ port of entry) |
| Mexican states on the route | Sonora (Level 3) |
| Fuel estimate (car at 25 mpg) | about 9.8 gal; actual use varies by vehicle and traffic |
| Stops listed below | 5 |
Crossing into Mexico: what you need for Sonoyta
| Passport | Passport book or passport card to enter Mexico by land |
|---|---|
| FMM entry permit | Not needed if you stay within 12 miles (20 km) of the border for 6 days or less; required for longer stays or if you travel farther in |
| Temporary vehicle import permit (TIP) | Not needed: Sonoyta is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit |
| Mexican auto insurance | Required for all vehicles: buy a Mexican policy before you cross |
Sources: U.S. State Department, Mexico travel information (updated August 11, 2026); permits are issued by Banjercito. Sonora free zone: Explore Sonora.
Crossing at Lukeville
Lukeville is a small port at the south end of Arizona State Route 85, across from Sonoyta, Sonora. It is the main road gateway for Arizonans heading to Puerto Peñasco (Rocky Point) on the Sea of Cortez, via Mexico Federal Highway 8.
What the drive from Bisbee to Sonoyta is like
AZ 86 (118 mi) and AZ 90 (47 mi) carry about 67% of the 245 miles. The U.S. part of the drive runs through Arizona for about 244 miles; after the border at Lukeville you are practically in Sonoyta. Of the 5 stops listed below, 2 are within a mile of the road.
The route from Bisbee to Sonoyta, road by road
| Road | Route miles (from–to) | Length, mi | State |
|---|---|---|---|
| local roads | 0–1 | 1 | Arizona |
| AZ 80 | 1–7 | 6 | Arizona |
| AZ 90 | 7–54 | 47 | Arizona |
| connecting roads | 54–55 | 1 | Arizona |
| I-10 | 55–96 | 41 | Arizona |
| connecting roads | 96–98 | 2 | Arizona |
| AZ 86 | 98–216 | 118 | Arizona |
| AZ 85 | 216–243 | 27 | Arizona |
| local roads | 243–245 | 2 | Arizona, Sonora |
- Mile 244 of this route: Arizona → Sonora (international border)
Stops between Bisbee and Sonoyta
- Right off the route (under 1 mile): Kartchner Caverns State Park (mile 45), Organ Pipe Cactus National Monument (mile 238)
- Nature and outdoors: Murray Springs Clovis Site (mile 18), Kartchner Caverns State Park (mile 45)
- Museums and history: Murray Springs Clovis Site (mile 18), Pima Air & Space Museum (mile 89), Cathedral of Saint Augustine (mile 96), Organ Pipe Cactus National Monument (mile 238)
Murray Springs Clovis Site
Clovis hunters butchered large Ice Age animals here 12,000 to 13,000 years ago. A one-third-mile self-guided interpretive trail in the San Pedro Riparian National Conservation Area, about six miles east of Sierra Vista, tells the story.
Kartchner Caverns State Park
Discovered in 1974 in the Whetstone Mountains, this living limestone cave is seen on guided tours past formations like Kubla Khan, a 58-foot column, and a 21-foot soda straw; above ground, the park has trails and camping.
Pima Air & Space Museum
Open since 1976, Tucson's aerospace museum spreads across 80 acres with about 400 historic aircraft, ranging from a Wright Flyer to a Boeing 787 Dreamliner, shown outdoors and in six indoor exhibit hangars.
Cathedral of Saint Augustine
Mother church of the Diocese of Tucson, this downtown cathedral wears a 1928 cast-stone façade inspired by the Cathedral of Querétaro, Mexico, decorated with yucca and saguaro blossoms and a depiction of Mission San Xavier del Bac.
Organ Pipe Cactus National Monument
Near Ajo in the Sonoran Desert, this International Biosphere Reserve is the only place in the U.S. to see large stands of organ pipe cactus, with scenic drives, hiking trails, camping, and winter ranger programs.
When you get to Sonoyta
Sonoyta is the Sonoran border town opposite Lukeville, Arizona, a few miles south of Organ Pipe Cactus National Monument, and it is where Federal Highway 8 turns south toward Puerto Peñasco. That road leads to the visitor center of El Pinacate and Gran Desierto de Altar, a UNESCO World Heritage biosphere reserve of lava fields, giant craters and sand dunes.
- El Pinacate and Gran Desierto de Altar Biosphere Reserve: Inscribed by UNESCO in 2013, the reserve protects a dormant volcanic shield, ten deep circular craters and dunes up to 200 meters high. source
- El Elegante crater: The reserve's managers call El Elegante its most visited and most accessible crater; the visitor center is at km 52 of the Sonoyta–Puerto Peñasco highway. source
- Organ Pipe Cactus National Monument: Just across the border in Arizona, the monument's Kris Eggle Visitor Center is five miles north of the Lukeville crossing, and the park fronts 30 miles of the border. source
More drives to Sonoyta
- Lake Havasu City, AZ to Sonoyta
- Escondido, CA to Sonoyta
- Kanab, UT to Sonoyta
- Venice Beach, CA to Sonoyta
- Camarillo, CA to Sonoyta
- La Quinta, CA to Sonoyta
From Bisbee to other places in Mexico
- Bisbee, AZ to San Felipe
- Bisbee, AZ to Tecate
- Bisbee, AZ to San Carlos
- Bisbee, AZ to Cananea
- Bisbee, AZ to San Luis Río Colorado
- Bisbee, AZ to Delicias
All routes to Sonoyta, border crossings and permits in one place: Driving to Sonoyta, Mexico from the U.S.
Continue Your Adventure
Frequently asked questions
How long is the drive from Bisbee to Sonoyta?
About 4 h 59 min of driving without stops, over 245 miles.
How far is Sonoyta from Bisbee by car?
About 245 miles (395 km) on the Wayro route. Other map services may show a few miles more or less, depending on where they start and end in each city.
Where does the Bisbee to Sonoyta drive cross into Mexico?
At about mile 244 of this route, from Arizona into Sonora, near the Lukeville port of entry.
Do I need a permit to drive my car from Bisbee to Sonoyta?
No vehicle permit is needed. Sonoyta is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit. You also need Mexican auto insurance and a passport book or card.
Is it safe to drive from Bisbee to Sonoyta?
The U.S. State Department rates Sonora Level 3: Reconsider Travel (advisory issued May 29, 2026). Read the full advisory before you go.
What roads does the drive from Bisbee to Sonoyta use?
In order: AZ 80, AZ 90, I-10, AZ 86 and AZ 85. The road-by-road table above shows the route miles and states for each one.
What are good stops between Bisbee and Sonoyta?
Closest to the road: Kartchner Caverns State Park (state park, mile 45, 0.2 mi from the route); Pima Air & Space Museum (aviation museum, mile 89, 1 mi from the route); Organ Pipe Cactus National Monument (National monument, mile 238, 0.3 mi from the route). All stops are described above.
How we put this guide together
Wayro calculates the route from OpenStreetMap road data; mile numbers are positions along this route, not highway mile markers, and "from the route" distances are straight-line, so the real detour depends on access roads. Stops are chosen from parks, natural sites, museums, historic sites and attractions close to the route (roughly 2 to 7 miles depending on the type, farther for World Heritage sites): at least one strong stop for each stretch of the drive, then the best-known places nearest the road, with no more than five of one type, up to nine in all. Places that are closed, private or not open to visitors are removed. Place and city descriptions are written by the Wayro team from official park, museum, tourism and government websites and other published sources. Safety levels and entry rules were checked against the U.S. Department of State on September 29, 2026. Conditions change, so check the linked sources before you travel.
Route data © OpenStreetMap contributors.