The Wayro route from Silver City to Hermosillo is 400 miles (644 km), about 7 h 18 min of driving without stops. The U.S.–Mexico border is at about mile 227 on this route, near the Nogales port of entry.
| Distance | 400 mi (644 km) |
|---|---|
| Driving time, no stops | 7 h 18 min |
| Main roads, in order | NM 90 → I-10 → AZ 90 → AZ 82 → MEX-15 → MEX-15D |
| Border crossing | about mile 227 of this route, Arizona → Sonora (near the Nogales, AZ port of entry) |
| Mexican states on the route | Sonora (Level 3) |
| Toll roads | MEX-15D |
| Fuel estimate (car at 25 mpg) | about 16.0 gal; actual use varies by vehicle and traffic |
| Stops listed below | 5 |
Crossing into Mexico: what you need for Hermosillo
| Passport | Passport book or passport card to enter Mexico by land |
|---|---|
| FMM entry permit | Required for this trip: Hermosillo is well beyond the 12-mile (20 km) border zone where the permit is not needed |
| Temporary vehicle import permit (TIP) | Not needed: Hermosillo is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit |
| Mexican auto insurance | Required for all vehicles: buy a Mexican policy before you cross |
Sources: U.S. State Department, Mexico travel information (updated August 11, 2026); permits are issued by Banjercito. Sonora free zone: Explore Sonora.
Crossing at Nogales
Nogales, Arizona, and Nogales, Sonora, share several crossings: DeConcini downtown is the main gateway for visitors and daily crossers, Morley Gate nearby serves pedestrians, and Mariposa on the west side handles commercial trucks. The city is also home to Arizona's only rail crossing.
What the drive from Silver City to Hermosillo is like
MEX-15D (112 mi) and I-10 (109 mi) carry about 55% of the 400 miles. The U.S. part of the drive runs through New Mexico, Arizona for about 227 miles; after the border at Nogales you have about 173 miles left in Mexico. The Mexican leg uses MEX-15D, a toll highway (cuota). Of the 5 stops listed below, 4 are within a mile of the road.
The route from Silver City to Hermosillo, road by road
| Road | Route miles (from–to) | Length, mi | State |
|---|---|---|---|
| local roads | 0–1 | 1 | New Mexico |
| NM 90 | 1–42 | 41 | New Mexico |
| connecting roads | 42–46 | 4 | New Mexico |
| I-10 | 46–155 | 109 | New Mexico, Arizona |
| connecting roads | 155–156 | 1 | Arizona |
| AZ 90 | 156–175 | 19 | Arizona |
| AZ 82 | 175–224 | 49 | Arizona |
| connecting roads | 224–226 | 2 | Arizona |
| MEX-15 | 226–278 | 52 | Arizona, Sonora |
| MEX-15D | 278–390 | 112 | Sonora |
| local roads | 390–400 | 10 | Sonora |
- Mile 67 of this route: New Mexico → Arizona (state line)
- Mile 227 of this route: Arizona → Sonora (international border)
Stops between Silver City and Hermosillo
- Right off the route (under 1 mile): Lordsburg-Hidalgo County Library (mile 44), The Thing (mile 135), Texas Canyon (mile 138), Kartchner Caverns State Park (mile 165)
- Nature and outdoors: Texas Canyon (mile 138), Kartchner Caverns State Park (mile 165), Patagonia Lake State Park (mile 212)
- Museums and history: Lordsburg-Hidalgo County Library (mile 44)
Lordsburg-Hidalgo County Library
Built in 1936–37 as a Works Progress Administration project, this single-story adobe library in Lordsburg keeps its original floor plan and stained glass windows, and it's listed on the National Register of Historic Places.
The Thing
Billboards along I-10 between El Paso and Tucson build up to this bright yellow stop about an hour east of Tucson, where a small museum shows off a collection of bizarre objects and the gift shop sells odd souvenirs.
Texas Canyon
Just off Interstate 10 between Benson and Willcox, giant granite boulders scatter across high-desert grassland. The Amerind Foundation's Texas Canyon Nature Preserve offers about 6 miles of gentle trails past balanced rocks and spires.
Kartchner Caverns State Park
Discovered in 1974 in the Whetstone Mountains, this living limestone cave is seen on guided tours past formations like Kubla Khan, a 58-foot column, and a 21-foot soda straw; above ground, the park has trails and camping.
Patagonia Lake State Park
Tucked into the rolling hills of southeastern Arizona, this lake park draws visitors for fishing, water skiing, camping and a creek trail where birders watch for herons, vermilion flycatchers and hummingbirds.
When you get to Hermosillo
Hermosillo, the capital of Sonora, spreads across the Sonoran Desert on Federal Highway 15. The rocky Cerro de la Campana rises right beside downtown, and stone quarried from it built the 1908 state penitentiary that now holds the regional history museum. The cathedral and Plaza Zaragoza anchor the old center, a short walk from the Government Palace.
- Museo Regional de Sonora: INAH runs this museum inside the old state penitentiary, built of Cerro de la Campana stone in 1908 and used as a prison until 1979. source
- Cerro de la Campana: The city's landmark hill gives a panoramic view over Hermosillo, and its phonolite rocks ring like a bell when struck, which gave it its name. source
- Catedral de la Asunción: Dedicated to the Virgin of the Assumption, the cathedral on Plaza Zaragoza blends Baroque and neo-Gothic elements in an eclectic facade. source
Hermosillo Cathedral
Consecrated in 1908, the Cathedral of Our Lady of the Assumption pairs an eclectic facade of Baroque and neo-Gothic elements with a neoclassical interior; its dome was finished in 1963. A small 18th-century chapel once stood here.
More drives to Hermosillo
- Payson, AZ to Hermosillo
- Show Low, AZ to Hermosillo
- Coolidge, AZ to Hermosillo
- San Diego, CA to Hermosillo
- Apache Junction, AZ to Hermosillo
- Williams, AZ to Hermosillo
From Silver City to other places in Mexico
- Silver City, NM to Mexicali
- Silver City, NM to Nuevo Casas Grandes
- Silver City, NM to Creel
- Silver City, NM to Bahía de Kino
- Silver City, NM to Magdalena de Kino
- Silver City, NM to Cuauhtémoc
All routes to Hermosillo, border crossings and permits in one place: Driving to Hermosillo, Mexico from the U.S.
Continue Your Adventure
Frequently asked questions
How long is the drive from Silver City to Hermosillo?
About 7 h 18 min of driving without stops, over 400 miles.
How far is Hermosillo from Silver City by car?
About 400 miles (644 km) on the Wayro route. Other map services may show a few miles more or less, depending on where they start and end in each city.
Where does the Silver City to Hermosillo drive cross into Mexico?
At about mile 227 of this route, from Arizona into Sonora, near the Nogales port of entry.
Do I need a permit to drive my car from Silver City to Hermosillo?
No vehicle permit is needed. Hermosillo is inside Sonora's free zone (west of Highway 15 as far south as Empalme, plus a strip along the border that includes Cananea). Going farther south or east of Highway 15 requires a permit. You also need Mexican auto insurance and a passport book or card. An FMM entry permit is required too.
Is it safe to drive from Silver City to Hermosillo?
The U.S. State Department rates Sonora Level 3: Reconsider Travel (advisory issued May 29, 2026). Read the full advisory before you go.
What roads does the drive from Silver City to Hermosillo use?
In order: NM 90, I-10, AZ 90, AZ 82, MEX-15 and MEX-15D. The road-by-road table above shows the route miles and states for each one.
What are good stops between Silver City and Hermosillo?
Closest to the road: The Thing (roadside attraction, mile 135, 0.2 mi from the route); Texas Canyon (canyon, mile 138, 0.1 mi from the route); Kartchner Caverns State Park (state park, mile 165, 0.2 mi from the route). All stops are described above.
How we put this guide together
Wayro calculates the route from OpenStreetMap road data; mile numbers are positions along this route, not highway mile markers, and "from the route" distances are straight-line, so the real detour depends on access roads. Stops are chosen from parks, natural sites, museums, historic sites and attractions close to the route (roughly 2 to 7 miles depending on the type, farther for World Heritage sites): at least one strong stop for each stretch of the drive, then the best-known places nearest the road, with no more than five of one type, up to nine in all. Places that are closed, private or not open to visitors are removed. Place and city descriptions are written by the Wayro team from official park, museum, tourism and government websites and other published sources. Safety levels and entry rules were checked against the U.S. Department of State on September 29, 2026. Conditions change, so check the linked sources before you travel.
Route data © OpenStreetMap contributors.