The Wayro route from Santa Ana to San Felipe is 326 miles (524 km), about 6 h 19 min of driving without stops. The U.S.–Mexico border is at about mile 203 on this route, near the Calexico West port of entry.
What the State Department tells travelers on this route:
- Baja California: “Travelers should remain on main highways and avoid remote locations.”
| Distance | 326 mi (524 km) |
|---|---|
| Driving time, no stops | 6 h 19 min |
| Main roads, in order | I-5 → I-805 → CA-52 → I-8 → CA-111 → MEX-5 |
| Border crossing | about mile 203 of this route, California → Baja California (near the Calexico West, CA port of entry) |
| Mexican states on the route | Baja California (Level 3) |
| Fuel estimate (car at 25 mpg) | about 13.0 gal; actual use varies by vehicle and traffic |
| Stops listed below | 9 |
Crossing into Mexico: what you need for San Felipe
| Passport | Passport book or passport card to enter Mexico by land |
|---|---|
| FMM entry permit | Required for this trip: San Felipe is well beyond the 12-mile (20 km) border zone where the permit is not needed |
| Temporary vehicle import permit (TIP) | Not needed: Baja California is in Mexico's hassle-free zone for U.S. vehicles |
| Mexican auto insurance | Required for all vehicles: buy a Mexican policy before you cross |
Sources: U.S. State Department, Mexico travel information (updated August 11, 2026); permits are issued by Banjercito.
Crossing at Calexico West
Calexico West sits in downtown Calexico, directly across from Mexicali, and GSA describes it as the main border crossing linking the Imperial Valley to Baja California. It handles passenger vehicles and pedestrians and is in the middle of a multi-phase federal modernization.
Sources: [1]
What the drive from Santa Ana to San Felipe is like
MEX-5 (124 mi) and I-8 (94 mi) carry about 67% of the 326 miles. The U.S. part of the drive runs through California for about 203 miles; after the border at Calexico West you have about 123 miles left in Mexico. Of the 9 stops listed below, 4 are within a mile of the road.
The route from Santa Ana to San Felipe, road by road
| Road | Route miles (from–to) | Length, mi | State |
|---|---|---|---|
| local roads | 0–2 | 2 | California |
| I-5 | 2–74 | 72 | California |
| connecting roads | 74–75 | 1 | California |
| I-805 | 75–78 | 3 | California |
| connecting roads | 78–80 | 2 | California |
| CA-52 | 80–93 | 13 | California |
| connecting roads | 93–96 | 3 | California |
| local roads | 96–99 | 3 | California |
| I-8 | 99–193 | 94 | California |
| connecting roads | 193–194 | 1 | California |
| CA-111 | 194–199 | 5 | California |
| connecting roads | 199–202 | 3 | California |
| MEX-5 | 202–326 | 124 | California, Baja California |
- Mile 203 of this route: California → Baja California (international border)
Stops between Santa Ana and San Felipe
- Right off the route (under 1 mile): San Onofre State Beach (mile 34), Legoland California (mile 58), San Elijo Lagoon (mile 66), Torrey Pines State Natural Reserve (mile 73)
- Nature and outdoors: San Onofre State Beach (mile 34), San Elijo Lagoon (mile 66), Torrey Pines State Natural Reserve (mile 73), Black's Beach (mile 74), Mission Trails Regional Park (mile 88), Yuha Desert (mile 173)
- Museums and history: Cabrillo National Monument (mile 80)
- With kids: Legoland California (mile 58)
San Onofre State Beach
The park covers three and a half miles of beach in San Diego County, including the San Onofre Bluffs and the Trestles surf break, which you reach on foot by a nature trail.
Legoland California
Designed for families with kids ages 2 to 12, this Carlsbad resort pairs rides and themed lands with Miniland USA's LEGO model of San Diego, a water park, and a SEA LIFE Aquarium.
San Elijo Lagoon
This 721-acre ecological reserve protects coastal wetland, riparian and coastal sage scrub habitat, with hiking trails that are popular for birdwatching.
Torrey Pines State Natural Reserve
Trails like the Guy Fleming Trail and the Razor Point and Yucca Point overlooks wind through sculpted canyons and rare Torrey pines with wide Pacific views, and paths drop to North and South Beach, best walked at low tide below unstable cliffs.
Black's Beach
This secluded stretch of sand below the Torrey Pines bluffs in La Jolla is officially part of Torrey Pines State Beach.
Cabrillo National Monument
The monument tells the story of Juan Rodríguez Cabrillo, who in 1542 became the first European to set foot on what is now the U.S. West Coast. It sits at the southern tip of the Point Loma peninsula.
Mission Trails Regional Park
Eight miles northeast of downtown San Diego, this city park offers about 60 miles of trails, boating on Murray Reservoir, and camping at Kumeyaay Lake. History buffs can see Old Mission Dam, built to store water for Mission San Diego de Alcalá.
Yuha Desert
South of Interstate 8 and west of El Centro, this Sonoran Desert basin holds Yuha Well, the favored water stop of the Anza expeditions of 1774–76. A State Historic Landmark plaque at the eastbound Sunbeam rest area on I-8 near Seeley tells the story.
Cerro Prieto
About 22 miles (35 km) south of Mexicali, this small rhyodacite lava dome rises above the desert floor and marks the surface of the Cerro Prieto Geothermal Field, one of Mexico's major geothermal resources.
When you get to San Felipe
Where the Baja desert runs straight into the warm Gulf of California, San Felipe is a fishing town about two hours south of Mexicali. It is known for sport fishing, dramatic low tides that pull the water far from shore, and seafood, especially the shrimp it celebrates with an annual festival.
- Valle de los Gigantes: South of town on the road to Puertecitos, this cactus reserve on Punta Estrella Ranch protects towering cardón cacti up to about 17 meters tall. source
- Sport fishing: Charters head into the Gulf of California from San Felipe, a town long known for sport fishing thanks to the abundance of marine species offshore. source
- Gulf beaches: The town's beaches are made for kayaking, paddleboarding and walking the wide flats exposed at low tide. source
More drives to San Felipe
- Safford, AZ to San Felipe
- Rancho Mirage, CA to San Felipe
- Coronado, CA to San Felipe
- Mesa, AZ to San Felipe
- Bisbee, AZ to San Felipe
- Casa Grande, AZ to San Felipe
From Santa Ana to other places in Mexico
- Santa Ana, CA to San Luis Río Colorado
- Santa Ana, CA to Sonoyta
- Santa Ana, CA to Puerto Peñasco
- Santa Ana, CA to Tecate
- Santa Ana, CA to Ensenada
- Santa Ana, CA to Guerrero Negro
All routes to San Felipe, border crossings and permits in one place: Driving to San Felipe, Mexico from the U.S.
Continue Your Adventure
Frequently asked questions
How long is the drive from Santa Ana to San Felipe?
About 6 h 19 min of driving without stops, over 326 miles.
How far is San Felipe from Santa Ana by car?
About 326 miles (524 km) on the Wayro route. Other map services may show a few miles more or less, depending on where they start and end in each city.
Where does the Santa Ana to San Felipe drive cross into Mexico?
At about mile 203 of this route, from California into Baja California, near the Calexico West port of entry.
Do I need a permit to drive my car from Santa Ana to San Felipe?
No vehicle permit is needed. Baja California is in Mexico's hassle-free zone for U.S. vehicles. You also need Mexican auto insurance and a passport book or card. An FMM entry permit is required too.
Is it safe to drive from Santa Ana to San Felipe?
The U.S. State Department rates Baja California Level 3: Reconsider Travel (advisory issued May 29, 2026). Read the full advisory before you go.
What roads does the drive from Santa Ana to San Felipe use?
In order: I-5, I-805, CA-52, I-8, CA-111 and MEX-5. The road-by-road table above shows the route miles and states for each one.
What are good stops between Santa Ana and San Felipe?
Closest to the road: San Onofre State Beach (state beach, mile 34, 0.1 mi from the route); Legoland California (amusement park, mile 58, 0.7 mi from the route); San Elijo Lagoon (nature area, mile 66, 0.1 mi from the route). All stops are described above.
How we put this guide together
Wayro calculates the route from OpenStreetMap road data; mile numbers are positions along this route, not highway mile markers, and "from the route" distances are straight-line, so the real detour depends on access roads. Stops are chosen from parks, natural sites, museums, historic sites and attractions close to the route (roughly 2 to 7 miles depending on the type, farther for World Heritage sites): at least one strong stop for each stretch of the drive, then the best-known places nearest the road, with no more than five of one type, up to nine in all. Places that are closed, private or not open to visitors are removed. Place and city descriptions are written by the Wayro team from official park, museum, tourism and government websites and other published sources. Safety levels and entry rules were checked against the U.S. Department of State on September 29, 2026. Conditions change, so check the linked sources before you travel.
Route data © OpenStreetMap contributors.